Phone:0086-371-55629010
Phone:0086-371-55629010
A steam drum is a standard feature of a water-tube boiler.It is a reservoir of water/steam at the top end of the water tubes. The drum stores the steam generated in the water tubes and acts as a phase-separator for the steam/water mixture.The difference in densities between hot and cold water helps in the accumulation of the "hotter"-water/and saturated-steam into the steam-drum.
Learn More
In small, low pressure boilers, steam-water separation can be established with the use of a large steam drum approximately half full of water.Natural gravity steam-water separation can be sufficient for this case. On the other hand, for high capacity, high pressure (HP) boilers, steam-water separation at the steam drum is accomplished with the use of mechanical steam-water separators.
Learn More
Double-Drum Coal Fired Industrial Boiler with High Quality Products advantages: 1.The rear is arranged by convection tubes densely connected to the drum 2.Improving the flow rate of flue gas heat transfer enhancement effect. 3.Adopts large optimized furnace arch, with light chain grate combustion equipment,and stepless speed regulation. FAQ:
Learn More
Double Drum Boiler Fuel Gas Product Introduction. SZS fuel oil （gas） saturation steam water tube boiler with double drum longitudinal type D layout design, boiler pressure stress of ontology in good condition, compression of drum, and other important components are not directly affected by high temperature flame radiation and scour, pressure parts retractile, thermal stress is small
Learn More
How to Destroy a Boiler -- Part 2 One of the most vulnerable areas is the interface where the tubes enter the drum at tube-baffle interfaces and refractory-to-tube interfaces. Poor water treatment system design - Double block and bleed valve systems should be used wherever any regenerant chemicals are introduced into the water system to
Learn More
The SZS is a typical D-type water tube boiler design, Bi-drum packaged gas & oil fired boiler. It is mainly composed by upper-drum (steam drum ) & lower-drum(water drum), membrane water cooling wall, convection bank, economizer, and condenser.
Learn More
SZL shop-assembled water tube steam boiler is the horizontal type double drum longitudinal type chain grate water tube steam boiler. The boiler is assembled with two drums and convection bank inside. Water wall tubes are placed on the left and right side of the burner. Moreover, there is a steam-water separator and surface blow down device that
Learn More
SECTION 23 52 33. WATER TUBE BOILERS. SPEC WRITER NOTES: Gauge Glass - Prismatic: Single or double (offset) tilted or vertical prismatic tempered borosilicate reflex units of sufficient length to include all low water cutoff points and high-water alarm point without discontinuity. Mounting: Pipe directly to boiler steam drum or to water
Learn More1. Two Drum Oil or Gas Fired Water Tube Boiler Two (double) drum oil or gas fired watertube boilers designs have progressed considerably over the years. At present, the walls have completely covered with a water-cooled surfaces. These walls are formed either by tubes touching each other, known as 'tangent tubes', or by tubes connected together
Learn More
The water flows through the smaller diameter boiler tubes while the combustion gases travel around them to transfer heat to the water. The boiler tubes in the watertube design carry the heated water inside the tubes between the lower drum (mud drum) and upper drums (steam drum), with the generated steam accumulating in the upper drum.
Learn More
These steam bubbles then come to the steam drum through riser and naturally separated from water and occupies the space above the water surface in the longitudinal drum of Babcock - Wilcox Boiler. Cross Drum Water Tube Boiler Construction of Cross Drum Water Tube Boiler. Cross Drum Boiler is essentially a variant of the Longitudinal Drum Boiler.
Learn More
water tube double-drum boiler factory | Boiler. horizontal double drum water tube boiler products, China horizont. SZL is assembling water tube steam boiler and double boiler barrel longitudinal type. chain grate steam boiler,which is make up of steam drum,water the bottom furnace wall,except the midfeather is setted on the scene,the other parts. is
Learn MoreThe total heating surface of a boiler includes all parts of the boiler which are exposed on one side of the gases of combustion and on the other side to the water and steam being heated The heating surface incudes: generating surface, generating tubes, screen tubes, waterwall tubes, support tubes, superheater surface, and economizer surface
Learn More
Steam drum is a collector and separator equipment for water and steam from water wall tubes. According to separation concept of water and steam in steam drum, separation process can be classified in three types such as natural gravity driven separation, baffle assisted primary separation and mechanical primary separation.
Learn More
Bi-drum boilers find its use in industrial steam generators very widely as they are capable of handling lot of load fluctuations. This is mainly due to the reason that the water reserve available is very high when compared to single drum. The single drum boilers can be designed for very high pressures and flows, even close to critical pressures.
Learn More